Forum Discussion

Karsty's avatar
Karsty
Explorer
Aug 19, 2013

RECALL ON SPRINTER EGR VALVE??

Has anyone received notification of a recall on newer Sprinter vans for an EGR valve issue??

I am currently away and my tenant contacted me and advised that the Mercedes dealer had called and wants me to bring my RV in for a "recall" regarding the EGR valve. They apparently told the tenant that it wasn't urgent but to have me contact them when I return.

I am now curious because I have been having some issues with a slight hesitation along with some "burping & farting" ... please forgive the technical terms ... on accelerating while going up hills. Not every time but just started periodically on this trip.
Class B

9 Replies

Sort By
  • Fastpaddler's avatar
    Fastpaddler
    Explorer
    Sep 02, 2013
    Thanks Shearwater. I will check with MB Service when I take it in for service. I have an extended warrantee which would cover it if it is defective.
    AL
  • dixied's avatar
    dixied
    Explorer
    Sep 01, 2013
    I have the 2011 chassis on my 2012 Roadtrek. There was a recall on the EGR valve. Mine was replaced when I got my 10,000 mile service back in February. I did NOT get any notification from Mercedes or Roadtrek. The only reason I know it happened is from going back and looking at the service record after reading your post.
  • Shearwater's avatar
    Shearwater
    Explorer
    Sep 01, 2013
    Fastpaddler - The EGR valve on our 2006 model was replaced at around 70,000 miles but it was done under warranty.
  • Fastpaddler's avatar
    Fastpaddler
    Explorer
    Sep 01, 2013
    My 2006 Sprinter Pleasureway Plateau TS is supposed to have its EGR replaced at 60K miles @ about $500! Mine seems ok but I was wondering if this is an essential part to replace along with fuel filter,oil filter, engine oil and transmission oil--at some point between 60K and 100K. ANy opinion on this?
    AL
  • Karsty's avatar
    Karsty
    Explorer
    Aug 20, 2013
    bobojay5 wrote:
    I believe this is on the 2010-2011 chassis Karsty. Not entirely sure if the whole 2012 model year chassis is included or not. Some changes were made in the mid-2012 chassis specs as far as fuel delivery is concerned also....
    You'll have to let everyone know


    That would appear to be the case Bob. Mine is the 2011 chassis and as it turns out my VIN is listed as needing the work done. The dealer will be able to tell anyone with a quick check of the VIN.
  • bobojay5's avatar
    bobojay5
    Explorer
    Aug 19, 2013
    I believe this is on the 2010-2011 chassis Karsty. Not entirely sure if the whole 2012 model year chassis is included or not. Some changes were made in the mid-2012 chassis specs as far as fuel delivery is concerned also....
    You'll have to let everyone know
  • Karsty's avatar
    Karsty
    Explorer
    Aug 19, 2013
    Thanks folks ... the following information was sent to me from another fellow I know. I have already made my appointment and should be good to go.


    2011 Mercedes Benz SPRINTER gas recirculation valve (egr valve) service bulletin (Bulletin SC-2012120002)
    Bulletin Date: Feb. 1, 2013
    Component: Gas recirculation valve (egr valve).
    Bulletin Summary: Mercedes: the engine control module (ecm) may fail from feedback signal to valve due to humidity entering exhaust gas recirculation (egr) valve, causing an electrical short circuit and software needs updating. Model 2010-2011 906.
  • van_fl's avatar
    van_fl
    Explorer
    Aug 19, 2013
    VEHICLES BUILT ON 2008 SPRINTER CHASSIS. THE ENGINE CONTROL MODULE MAY NOT ACTUATE THE EGR VALVE SUFFICIENTLY TO PREVENT SOOT ACCUMULATION, RESULTING IN IMPROPER VALVE OPERATION OR STICKING.

About Motorhome Group

38,717 PostsLatest Activity: Apr 29, 2025