Diesel Winter Maintenance

Thank you all very much. I will take the majority advice and let it set. Can't really drive it this winter due to recovery from serious shoulder surgery. Thanks again.

Either let it sit or start it up and drive it hard under load. Letting it run for a few minutes is the worst thing you can do.

everyone is so worried about the engines when the oil hubs are the ones that suffer more then the engines will during non use

Agree with others. You aren't doing the diesel any good unless you drive it enough to warm it up, which is the best thing you can do for it.
Your biggest probelm will be the air brakes locking up on you after sitting a long time.

Idling for a few minutes is the absolute worst on any motor. All your doing is creating moisture thru condensation. This turns into acid, which eventually does inrepairable damage. Your much better leaving it sit all winter. Better yet, go drive it for a hour at highway speeds to get everything good and hot.

I don't really need to do this as the majority of the advice above is good, but I feel it will not hurt to have it reinforced by someone that was/is an engine professional.....

NOTHING GOOD HAPPENS WHEN AN ENGINE IS IDLED.

Diesels don't mind sitting at all.

Carburetor engines only have trouble because of fuel left in the carburetor. If you deal with that by draining or running it dry, then that is not a problem.

The people that advise that you periodically run an engine or genset, are the same people that sell parts......

Matt

Cold weather start ups are hard on engines. If they don't reach operating temperture then you are adding moisture to the exhaust sytem. Best to let them sit.

I go the other way. I start my diesels every month in the winter and let them warm up (until the temperature gauge is mid point which is usually a half hour. 3 farm tractors, and pickup truck.

I also add Power Service in the fall and a splash of biocide. Been down the algae road, it's expensive to eliminate.

Always did that with the big trucks (Road Tractors) that sat in the lot at the yard where I was employed.

I don't keep them on a Battery Tender either, I just isolate the batteries via a disconnect switch on each unit.

Don't run the engine unless you can drive it for at least 30 minutes. This allows the oil temperature to rise to the point where the moisture will evaporate. This won't happen at idle or even fast idle.

Run the genny once a month under load for 20-30 minutes to heat up the oil and dry out the windings.

diesels can sit for a year or more ,without doing anything to them. put good batteries in them and they fire right up. just think of all the farmers who leave there diesels sit from fall to spring. keep the battries on a trickle charge and let it sleep till spring.