Hi everybody!Quick question for you today.I'm building a campervan conversion out of a Ford E250 high top van.I'm new to all of this and it's my second year of building this thing (part time)I live in canada but I order a lot of equipment online in the USA and I have it delivered near the border then I go down to get it.I did that a couple of times now and I saved a lot of money (even if the exchange rate is not good for us)Most of the equipment is just sitting there in my garage with my campervan waiting for installation.Among the equipment, I have two 6 volt GC2 golf cart acid batteries that I bought at Sam's club in July (summer 2016)https://www.samsclub.com/sams/duracell-golf-car-battery-group-size-gc2/prod3590228.ipI wanted to know if it's ok to leave them there until I hook them up? or do I need to put a trickle charger/smart charger on them?My garage is not heated but it is connected to the rest of the house so it's around 50deg F most of the time, the coldest it will get is around 40deg F.Thanks for any advice!

Yes, you need to charge them and keep them charged. They probably were not fully charged when you bought them and they have been sulfating ever since.

beemerphile1 wrote:...they have been sulfating ever since.I'm guessing that's a bad thing :S but how bad? Did I damage them in a way that they will have less cycle life?

Yes, they have lost some capacity.Batteries self discharge, and they have shelf lives.They self discharge more with age, and with higher temperatures.YOu should fully charge them and then Ideally perform an Equalization charge, if the cells do not all read 1.275+ on a Hydrometer.Equipment and processes for doing this have been discussed in depth dozens of times on this forum.I have a freind who once purchased high$$ AGM batteries and never put them into use. Years later, he kept muttering they were brand new and never used, yet the voltmeter and charging sources proved theses new batteries were sulfated and worth only their weight in lead.Sadly this did not prevent him from repeating the unwise decision, and I go there with my charger every month and top them up, but they are now over 2 years old. 800$ worth of top quality battery wasting away, slowly. They'd be near useless if I did not top them up regularly. they are due now.

I'm on my way to buy a Hydrometer, I checked the forum and I'll be going with this hydrometer instead of the cheaper but more fragile glass model, is this a good choice?https://www.napacanada.com/en/p/USE62230

Not in my opinion. I have one of those and could not get the same reading twice.I like the OTC4619https://www.amazon.com/OTC-4619-Professional-Battery-Hydrometer/dp/B0050SFVHOJust do not throuw out the packaging and store it in there and Fragility is not an issue.

Golf cart batteries vs storage vs charging?? | Good Sam Community

Almot
Explorer III
Feb 25, 2017
evy wrote:
In order to plug the trickle/smart charger on the batteries I need to convert them to 12 volts, I need to buy a short wire to do so, is 4 gauge big enough? and which terminal do I use? the threaded one or the bigger one? from what I see on google image most people use the threaded one.

It's amazing that this project (5 months?) didn't end up in magnificent fireworks yet. Perhaps a sheer luck.

Yes, 4 gauge is big enough. 14 or 18 gauge will be sufficient. Any piece of old lamp cord. Terminal type doesn't matter, for this application.

For eventual use on a camping, that #4 cable from Canadian Tire will do.
DrewE
Explorer II
Feb 25, 2017
evy wrote:
In order to plug the trickle/smart charger on the batteries I need to convert them to 12 volts, I need to buy a short wire to do so, is 4 gauge big enough? and which terminal do I use? the threaded one or the bigger one? from what I see on google image most people use the threaded one.

For the trickle charger, pretty much any wire will do fine since the current is small (an amp or two at most). Look at the size of the wires from the trickle charger for a rough minimum guideline.

For eventual use in your van, the interconnect wire should be sized based on the current required by the van (or put out by the converter) in the worst case. Basically, that boils down to having it be the same size as the ground wire and the positive wire, assuming there's only one positive wire connected. 4 gauge would probably be fine if you don't have a large inverter. One or two gauge ought to be sufficient in most any case.

It doesn't really matter which terminals you use; whatever works for the terminations on the connecting wire. Most do use the wing nuts because most RVs have wires with ring terminals on them. The posts may be a little more secure if you have the proper size of clamp for the post, but both are satisfactory.
Boon_Docker
Explorer III
Feb 25, 2017
Almot wrote:
A good trickle charger wouldn't hurt. Better than leaving them disconnected for 7 months of winter. Montreal is not a North Pole, I suspect that of those 7 months only 2 or 3 months the temperature dropped below 50F and/or didn't stay below 50 all day. With cheap chargers rarely being good, I would still check the voltage once a month or so.

Good point. A trickle charger would be good idea where the OP is at.
We don't experience tropical temperatures here in the Alberta foothills in the winter like they do in Montreal.
evy
Explorer
Feb 25, 2017
In order to plug the trickle/smart charger on the batteries I need to convert them to 12 volts, I need to buy a short wire to do so, is 4 gauge big enough? and which terminal do I use? the threaded one or the bigger one? from what I see on google image most people use the threaded one.

Is this 15" wire suitable for the job?

http://www.canadiantire.ca/en/pdp/motomaster-switch-to-starter-battery-cable-4-gauge-0110961p.html#srp

https://www.samsclub.com/sams/duracell-golf-car-battery-group-size-gc2/prod3590228.ip?xid=plp3990117-auto:product:1:1
Almot
Explorer III
Feb 25, 2017
A good trickle charger wouldn't hurt. Better than leaving them disconnected for 7 months of winter. Montreal is not a North Pole, I suspect that of those 7 months only 2 or 3 months the temperature dropped below 50F and/or didn't stay below 50 all day. With cheap chargers rarely being good, I would still check the voltage once a month or so.
DrewE
Explorer II
Feb 25, 2017
Do be aware that how long lead acid batteries can sit disconnected without self-discharging too much is highly dependent on the ambient temperature. Warmer temperatures mean much higher rates of self-discharge. Several months in winter temperatures is no problem; a month at summer in Florida temperatures would be quite problematic.
Boon_Docker
Explorer III
Feb 25, 2017
^
I do the same with my 6's. Leave them on the trailer (disconnected) and fully charge them in October and then fully charge them in May. They are 7 years old. Just checked them a couple days ago they are at 12.98 V.
I also dry camp 99 percent of the time and never let them go below 60 percent SOC.
Gjac
Explorer III
Feb 25, 2017
evy wrote:
Hi everybody!

Quick question for you today.

I'm building a campervan conversion out of a Ford E250 high top van.

I'm new to all of this and it's my second year of building this thing (part time)

I live in canada but I order a lot of equipment online in the USA and I have it delivered near the border then I go down to get it.
I did that a couple of times now and I saved a lot of money (even if the exchange rate is not good for us)

Most of the equipment is just sitting there in my garage with my campervan waiting for installation.

Among the equipment, I have two 6 volt GC2 golf cart acid batteries that I bought at Sam's club in July (summer 2016)
https://www.samsclub.com/sams/duracell-golf-car-battery-group-size-gc2/prod3590228.ip

I wanted to know if it's ok to leave them there until I hook them up? or do I need to put a trickle charger/smart charger on them?

My garage is not heated but it is connected to the rest of the house so it's around 50deg F most of the time, the coldest it will get is around 40deg F.

Thanks for any advice!
I have not had good luck with hydrometers, I have the one you posted and always got a reading of good or 1300. When I tested distilled water I still got the same reading. I also have the bulb type which I thought would be more accurate but was not. Some have told me I needed to buy a Freas to get an accurate reading, I just use a volt meter now. As to your second question If you fully charge your batteries you can leave them for several months until you get your system together. I have the same batteries and fully charge mine for the winter, disconnect then recharge in spring. I dry camp 95% of the time but never let them get below 50% SOC before recharging them. most cycles are much shallower and the batteries are 9 years old.
brulaz
Explorer
Feb 24, 2017
And just found a cheaper one referenced here:
http://forums.woodalls.com/index.cfm/fuseaction/thread/tid/29198695.cfm
brulaz
Explorer
Feb 24, 2017
landyacht318 wrote:
Not in my opinion. I have one of those and could not get the same reading twice.

I like the OTC4619

https://www.amazon.com/OTC-4619-Professional-Battery-Hydrometer/dp/B0050SFVHO

Just do not throuw out the packaging and store it in there and Fragility is not an issue.

Guess I'm just clumsy, as I keep breaking these things.
Are the refractometers you see on Amazon any good?
This one is quite a bit more expensive but has good reviews:
https://www.amazon.com/Robinair-75240-Coolant-Battery-Refractometer/dp/B000HTNODE