ONAN MARQUIS 5500

What was the problem?

Gjac wrote:
When you say generator "would not crank on" do you mean it would not crank(engine turn over) or the engine would crank but not start?

This has been taken care of.

When you say generator "would not crank on" do you mean it would not crank(engine turn over) or the engine would crank but not start?

Here is a direct replacement for your Onan.
https://www.amazon.com/Electric-Replacement-149-2620-A029F887-Generator/dp/B07WDXZKTM

Sounds like the problem I had. The electric fuel pump gets hot and stops. It is a low pressure one, around three pounds.

https://www.amazon.com/Universal-Electric-2-3-5psi-Gasoline-Carburetor/dp/B07MLR5BS8

Jaybird wrote:
1) MODEL # 5.5BGMFA26105H
2)S/N F990927686

Ran for one hour both a/c's front and rear operated great

laptop computer also working

one hour in gen made a cranking noise shut off and would not crank on.

Got up this a m and it fired up no problem

How many hours on the gen and have you checked the brushes? Do you have the service manual ?

On another forum somebody suggested
"May be equipped with overheat switch, electric current draw to high. Check amp draw on AC units"

If this was the case, and the current draw too high, why would they both run for over an hour"

Charley67 wrote:
Enough fuel in your tank?

1/2 tank of gas(fresh)

Enough fuel in your tank?

1) MODEL # 5.5BGMFA26105H
2)S/N F990927686

Ran for one hour both a/c's front and rear operated great

laptop computer also working

one hour in gen made a cranking noise shut off and would not crank on.

Got up this a m and it fired up no problem