Hello All,My Kwikee power step has stopped retracting. The motor runs and makes a clunking grinding sound for about 10 seconds but the step does not retract.The motorhome is a 2011 Winnebago and the motor on the step was replaced just over a year ago.Nothing looks out of place or broken, could it be binding or need lube.Any suggestions would be greatly appreciated.

Sounds like the gears are stripped. Need to take it apart to check. Still under warranty ?

While you're at it, use compressed air or whatever it takes and clean all the joints well, then lubricate.Maybe dirt and the lack of lubrication helped cause your problem?It's good PM.

I know this always sounds so terrible to suggest...but take a hammer and tap the motor housing for the step a few times! Sounds Crazy but I did this for year's until finally replacing the motor and still, infrequently, I have to tap away to get the steps to retract.

Seems like it is binding but the grinding sound might be the gears as you say.I'll give it a look and see.

Your main drive gear has broken teeth. You may be able to drop the motor and rotate that round gear in the gear housing past the broken tooth and it will still work. Doug

Kwikee Step won't Retract | Good Sam Community

royt911
Explorer
Aug 31, 2016
My 96 Winnebago Adventurer steps don't go out or in all the way. I disconnected the motor to check the linkage. It starts out loose for a few inches then gets harder to push in until it is in all the way. Once in it comes out a few inches the again gets harder to pull until it is out all the way. Is that normal or should it be the same resistance all the way in and out?

A video I took:

https://youtu.be/5ZNzYeIq1Kw
tstryk
Explorer
Sep 01, 2016
TAB1998 wrote:
Mine is a 1999 Allegro Bay with the Kwikee Steps (I think series 32)...it's a double step. I was having similar problems but I could help mine in. Finally two days ago it quit altogether. A little hum, a click and nothing. I read on another site that the left front window lift motor from a '86-'95 Ford Taurus would work. I went to my local AutoZone and they had one on the shelf for $42.99. I took my old motor/gear off the steps, swapped out the large gear from the old one to the new one, bolted it back in, cut and reconnected the wiring (same color wiring on both the old and new) and it came back to life. It fully retracts (which it hadn't done since I bought it) and fully extends. I don't remember the Autozone part number but it came with a Dorman label and part number 742-277. Hope that helps someone!

I tried the same thing, but it didn't fit. BUT - I thought it looked very familiar, so I asked to see a motor from a ford truck (I had just replaced the window motors in mine) and it fit! $29 vs $100+ for a "real" step motor. 2 years and it still works fine.

Forum Discussion

Kwikee Step won't Retract

About Motorhome Group

Related Content

Kwikee steps

Kwikee Steps Won't Extend

Kwikee Step retraction

Kwikee Jacks Fail To Retract

Kwikee Step