Cat C7 fuel filters

Again for reference if folks are interested, here's an old thread of mine on irv2.com that may be useful: Relocated Fuel Filter & Added Priming Pump

Brett: Although you may be able to mount the primer pump having to open up the closet or under bed just to change a fuel filter is one big pain. There are actually some MH's where you must undo the fasteners that hold down the bed frame before undoing the floor plate! Relocating is the answer.

Moisheh

cbeierl wrote:
Just for reference, here's the secondary filter on my 350HP C7 (before I relocated to the rear for easier access).

Yup, that is the standard location and orientation from the Caterpillar factory for the secondary fuel filter. Note the block-off plate on the upper left of the filter base where you can easily mount a Caterpillar manual primer pump.

If it is truly the sec filter you are viewing, I agree it's sounds like a good time to relocate it and add the manual priming pump. In addition to avoiding a major mess when removing the old filter this mod will make the changing the fuel filter(s) a simple and clean job. Good luck.

Lou
05 Travel Supreme Envoy
CAT C-7

Just for reference, here's the secondary filter on my 350HP C7 (before I relocated to the rear for easier access).

jdevans22 wrote:
Yes the filter is mounted with the threads down.

So that I understand this, if your secondary fuel filter is upside down, removing the filter (unless you open the drain plug on the filter base) will pour the contents out.

Said another way, looking from ABOVE, you don't see the filter base, you see the bottom of the filter. Never saw that arrangement.

Would SURE change it if it were mine.

On my C7 330hp cat there is a round canister on top of the engine but that is not a fuel filter on mine. Mine only came with one fuel filter which was the water separter and I had to have added the second fuel filter with the primer pump. Just make sure that the canister on top of your engine is really a fuel filter.

Yes the filter is mounted with the threads down.

Be aware that you can relocate that Caterpillar secondary filter to any location you like. All you need is to remount it and get longer hoses. You leave it after the lift pump, as it is now, but it's physical location is up to you (or a lazy coach maker who did not relocate it.

Our current and last coach both had the same Caterpillar secondary fuel filter, but both had a manual primer pump (which is easy to add-- just replace the block off plate held by two bolts) AND it was located where it was easily serviceable from the side of the coach.

Discussion from a few days ago.

C7 filter discussion clicky

Bill