Fridge is cycling on and off every 10-15 seconds

With the CAMCO kit, you do not. The idea is that it creates the flow from above. Fan, Vent Cover and Solar Panel are all one piece. Remove then Reinstall Four Screws and you're done. Many techs put sealant over the screw heads.
$77.48 on Amazon.

How did u run the wire down inside your rig to get to your coils?

ashnic wrote:

ktmrfs wrote:
ok, here is the likely issue. First the good news. Outback did the fridge install as dometic outlines, proper baffling, proper venting, and including the thermostatically controlled 12V fan across the coils in the proper location. Makes for good fridge operation, good and cold etc. etc.

So what's the problem??? Well, something you likely won't get dometic or a dealer to fix for free, and it's time consuming. The issue is that on some dometic fridges the thermostatic button either comes loose or partially fails and ends up with a too close on/off temperature difference. So you get the cycling. To fix it means pulling the fridge to get access to the fan and thermoswitch, since it is about half way up the stack.

I've know mutliple folks with properly installed fridges that have experienced this issue.

What you'll likely find is it happens most at moderate temperatures. Hot days the fan will run almost continously. Cold days it won't come on, Nice days, it cycles on and off.

Mine worked fine till this last summer, when it started acting up.

So what can you do?? Fortunetly one fix is reasonably easy,

1) get one of the solar fan kits and install it. This will keep enough air flowing and without very much noise, so the normal fan never comes on. There are several options, one has a solar panel that fits on the fridge top vent cover. and mount the fan either at the top of the vent. (requires cutting and replacing the screen) or drop the wire down the stack and mount the fan at the bottom of the compartment. I did this mod, and it stopped the cycling of the normal fan completely.

2) Live with it. It isn't hurting anything, other than what can be an anoying noise when everything in the trailer is quite.

and it has nothing to do with power source, AC or propane.

How would I go about mounting the solar panel..I have never done anything like that but doesn't sound like it would be to difficult..

see the post from DE bishop. The camco system is what I used, works fine. There are other less expensive solar fridge fans, but they take a little more DIY mounting.

D.E.Bishop wrote:
There is a complete solar fan assembly by CAMCO, Solar Refrigeration Roof Vent System, Camco Number - 42165. I think that everything you need to install the system is included except, being handy, tools and a nice overcast day to get on top of the rig.

I forgot, the system's MSRP is $146.00. Search the net and I'm sure you can save 15-25%.

that's what I used, got it on amazon for under $100.

There is a complete solar fan assembly by CAMCO, Solar Refrigeration Roof Vent System, Camco Number - 42165. I think that everything you need to install the system is included except, being handy, tools and a nice overcast day to get on top of the rig.

I forgot, the system's MSRP is $146.00. Search the net and I'm sure you can save 15-25%.

ktmrfs wrote:
ok, here is the likely issue. First the good news. Outback did the fridge install as dometic outlines, proper baffling, proper venting, and including the thermostatically controlled 12V fan across the coils in the proper location. Makes for good fridge operation, good and cold etc. etc.

So what's the problem??? Well, something you likely won't get dometic or a dealer to fix for free, and it's time consuming. The issue is that on some dometic fridges the thermostatic button either comes loose or partially fails and ends up with a too close on/off temperature difference. So you get the cycling. To fix it means pulling the fridge to get access to the fan and thermoswitch, since it is about half way up the stack.

I've know mutliple folks with properly installed fridges that have experienced this issue.

What you'll likely find is it happens most at moderate temperatures. Hot days the fan will run almost continously. Cold days it won't come on, Nice days, it cycles on and off.

Mine worked fine till this last summer, when it started acting up.

So what can you do?? Fortunetly one fix is reasonably easy,

1) get one of the solar fan kits and install it. This will keep enough air flowing and without very much noise, so the normal fan never comes on. There are several options, one has a solar panel that fits on the fridge top vent cover. and mount the fan either at the top of the vent. (requires cutting and replacing the screen) or drop the wire down the stack and mount the fan at the bottom of the compartment. I did this mod, and it stopped the cycling of the normal fan completely.

2) Live with it. It isn't hurting anything, other than what can be an anoying noise when everything in the trailer is quite.

and it has nothing to do with power source, AC or propane.

How would I go about mounting the solar panel..I have never done anything like that but doesn't sound like it would be to difficult..

ashnic wrote:
Thanks for the great info..I am pretty handy but have never pulled a fridge..is it that difficult?

Not real difficult.

Remove the outside cover to the fridge, disconnect gas line (make sure tanks are off), loosen 2 screws where 12V connects at the bottom (check color coding and/or mark them before disconnecting). Unplug 110v plug.

There are 2 screws in the "tracks" at the bottom into the plywood floor. Remove then go inside.

Remove the cover with the eyebrow controls. It pretty much just pulls straight out. Two screws up into the trim above fridge. Remove trim at the bottom, again it just pulls straight out and remove 2 more screws.

There could be screws at the side going into the trim beside the door.

Go outside and push gently. It should move inward a little bit. This is where it gets a little tricky. Go inside and create some type of platform for the refer to slide out onto. I use an old tub with a piece of plywood that matches the height of the bottom of the fridge.

Grab the fridge and slide it out onto the "platform". Takes me about 10 minutes to remove one.

Reverse to install.

Positive it is coming from under the fridge...I only turned it off for a couple of mins earlier..but will check it again tomorrow after getting home..

ashnic wrote:
Thanks for the great info..I am pretty handy but have never pulled a fridge..is it that difficult?

I haven't pulled one either. But from looking at it, I'd say more time consuming and akward than difficult. And once it's out setting it someplace where you won' damage the floor or carpet.

But there are plenty of folks who have, hopefully someone can chime in and post their experiece.

ashnic wrote:
Also we are camping at the moment, I turned the fridge off and it is still cycling..would that be normal?

Hum.... I would expect the fan to be on the switched side of the fridge power, so, with the fridge off it shouldn't cycle. But then I could very well be wrong.

and the fridge coils will stay warm for some time after you turn it off. if it is hooked to a 12V unswitched line, it could take 1+ hours before it quits cycling.


Are you sure the noise is from the fridge and not the WFCO converter across from the fridge??? It will cycle on and off. the rate is dependent on how much accessory current draw there is.

And there is no reason to turn off the fridge if you need it. the cycling fan won't hurt anything, just be anoying.