Water Heater

Thanks for the update.

It's always good to hear the solution to a problem on here.

OK tried the WH and it's working yeah!
The electric switch does not light up so that will be replaced
THANKS TO YOU GUYS FOR ALL YOUR HELP AND ENCOURAGEMENT
Richard

Removed the panel and found purple wire disconnected from the propane switch and now that light is working. Would that keep WH from lighting up on propane?

roachcoach wrote:
OK I need some help with the electric and propane switch . Where do I start to check why the switch doesn't light up. First of all the electric water heater is working just fine except for the light. The propane water heater is not.

My electric on switch does light up this is separate from propane fault light. If electric is working then its the switch or Jumper wire is off

My switch light for the electric water heater burns out every couple years.

Here is a copy of my notes when I had to order new switches.

**********************************
SIGMA SWITCHES
4703 WYLAND DRIVE
ELKHART IN 46514

800-488-9505
=======================================================
ROCKY AT SIGMA 1/29/07 will ship tuesday. ups free
A1-31 SWITCH FOR WATER HEATER, BLACK PLASTIC, RED LITE 3 EACH
ZU-12-14 WHITE PLASTIC, RED LIGHT 3 EACH
ZU-03-14 BLACK PLASTIC, RED LITE 3 EACH

*********************************

Your WH uses just one set of t-stats for both electric & propane heat control, uses the same DC fused power for both so if it works on electric OK but doesn't fire on propane then it is isolated to just the propane components.

That could be faulty Propane On/OFF switch
Could be the Spark Electrode or the firing circuit on control board

Need to test/check that you have 12V DC FROM the Propane On/Off Switch with switch on.........you have 12V DC to the switches cause electric & propane use same fused source.


VS pulling switch panel you can test/check for the 12V DC on ORANGE wire at connector on control board (outside compartment)

With 12V DC to/thru On/Off switch and to control board it then comes out on Brown wire thru a 'thermal fuse' to/thru Normal t-stat back to board on Brown wire.
Then out of control board on Red wire to/thru ECO to gas valve solenoids. (SAME CIRCUIT WHEN USING ELECTRIC)

Only difference on propane is when it comes out on Red wire to/thru ECO the Spark Electrode should be Firing (strong, loud spark----click,click,click)
No sparking then electrode could be bad, could have wrong spark gap (1/8"), high voltage wire from transformer on control board to spark electrode is bad or not making good connection OR the gas firing circuit on control board is bad.

It ALL has to do with getting a SPARK

Trace the 12V DC using a meter.....find where it stops




Wanna check whether FAULT light comes on......
With Electric ON go pull RED wire off of ECO.
Fault light DC power comes from control board on Blue wire

GPWayne wrote:
As you said the electric water heater is working just fine except for the light.
The bulb in the switch is burned out...This is very common. Easy fix, replace the switch.

The propane water heater should not start if the tank is full off hot water,,,,, heated by the electric heater element.

OK I'll replace the switch should be an ez job.
Today I run all the hot water out until it was running cold and had left the propane switch on for the WH to light up but never did.
With a air gun I blew all the inside of the WH with air nozzle, checked the fuses but still wouldn't light. Any ideas on what to check next?
Thanks

As you said the electric water heater is working just fine except for the light.
The bulb in the switch is burned out...This is very common. Easy fix, replace the switch.

The propane water heater should not start if the tank is full off hot water,,,,, heated by the electric heater element.

roachcoach wrote:
GCH10A-4E Atwood

GAS Combo Heat Exchanger 10gallon AScrew in Element 4th version Electronic ignition

Fault Light

Propane fails to light off/WH locks out

OR

ECO (HI Temp T-stat) Opens (180*F) because Normal T-stat failed to open (140*F)
When On electric or propane.......any time it opens

GCH10A-4E Atwood